Research experiments on carbon dioxide and activated carbon

Answers:0   |   LastUpdateAt:2021-06-16 18:50:55  

Question
visitor
 
Asked at 2021-06-16 18:50:55

Natural gas purification wastewater is mainly divided into normal production wastewater and maintenance wastewater.

The concentration of pollutants in normal production wastewater is low and can be treated by general biochemical treatment.china activated carbon 

The maintenance sewage contains a large number of complex biodegradable substances, biodegradability is poor, for many years mainly rely on fresh water dilution treatment and combustion furnace treatment, but these two methods are low efficiency and high cost, so it is necessary to develop new wastewater treatment methods.carbon pellets manufacturer 

Although we have studied the upflow anaerobic sludge bed reactor (UASB) for the treatment of high concentration sewage of the natural gas purification plant, the start-up test results of 133 days show that the effluent COD removal rate is only about 40% when the influent COD is 6000mg/L, and the treatment effect is not good.

Therefore, it is of practical significance to explore and seek an effective pretreatment method.

In this paper, Fenton oxidation and activated carbon adsorption were combined to pretreat the wastewater from natural gas purification maintenance, in order to improve the subsequent operation efficiency of UASB.

This experiment by orthogonal test to determine the Fenton reagent oxidation first preliminary operating conditions, on this basis, carries on the single factor analysis method, the main factors influencing the Fenton reagent treatment effect for each study, investigation of its influence on wastewater COD removal rate, the results show that Fenton oxidation method the optimum operating conditions for natural gas purification overhaul wastewater treatment: HO2 dosing quantity 0.3 mol/L, n (HO)/n (Fe) = systematically, initial pH = 3, reaction temperature 70 ℃, reaction time, 40 min.

Under these conditions, the COD removal rate reached 78.6%, the BOD /COD value increased from 0.168 to 0.353-0.403, and the biodegradability was greatly improved.

If Ho is added in three times and the interval time is 10min, the COD removal rate will increase from 78.6% to 80.3%. Therefore, it can be seen that H0: batch addition will further improve the reaction effect. 

Answers

This Question:"Research experiments on carbon dioxide and activated carbon" No answers yet. Be the first!
Related Questions
1
  • Answer This Question:Research experiments on carbon dioxide and activated carbon